![]() |
R1 & R6 Woolich Racing Kits |
Post Reply ![]() |
Author | |
rbengineering2010 ![]() fast Group ![]() ![]() Joined: 24 December 2013 Location: Gloucestershire Status: Offline Points: 227 |
![]() ![]() ![]() ![]() ![]() Posted: 03 October 2014 at 15:28 |
Hi guys, the new Woolich Racing ECU Flashing kits are now available for the 2007-14 R1 & 2006-11 R6.
Price is £225.00p including all software & hardware required to flash on bike. Bench Flashing Harnesses available also either individually or in the kit instead of the on bike harness at extra cost. More years to follow shortly. Thanks for looking Rich |
|
![]() |
|
RedDevil ![]() Instructor ![]() ![]() Joined: 02 December 2012 Location: Berkshire Status: Offline Points: 1016 |
![]() ![]() ![]() ![]() ![]() |
What gains are there to be had? Will you gain anything over a map on a power commander 5?
|
|
#92
|
|
![]() |
|
rbengineering2010 ![]() fast Group ![]() ![]() Joined: 24 December 2013 Location: Gloucestershire Status: Offline Points: 227 |
![]() ![]() ![]() ![]() ![]() |
Hi RedDevil, yes there are many gains over using a power commander, a properly mapped ECU will produce a sweeter running & faster bike, you can not only map your fuelling, but also:-
(2008-11 R6 for example) Ignition timing Electronic Throttle valve maps on Acceleration (Fly by Wire) Engine Braking Rev Limiter Fan Temperatures Motorised Velocity stack switch point by RPM Disable Fuel Cut on deceleration (this is worth having all on it's own, transforms the feel on the throttle) Disable pair valve Disable Stock 02 sensor Disable Steering Damper Alter Idle speed via temp compensation Fuel Injection timing Injector Balance Ignition Dwell and more.... Cheers Rich |
|
![]() |
|
RedDevil ![]() Instructor ![]() ![]() Joined: 02 December 2012 Location: Berkshire Status: Offline Points: 1016 |
![]() ![]() ![]() ![]() ![]() |
Can you do any maps that will work alongside a pc5? And do you have any before & after dyno graphs?
|
|
#92
|
|
![]() |
|
rbengineering2010 ![]() fast Group ![]() ![]() Joined: 24 December 2013 Location: Gloucestershire Status: Offline Points: 227 |
![]() ![]() ![]() ![]() ![]() |
Hi Matt, yes all the setting will work alongside a power commander but you will still need to map the fuelling with one or the other.
Not got any before and after dyno charts as yet myself, but there are plenty kicking around the internet. Cheers Rich
|
|
![]() |
|
carsonr6 ![]() Racer ![]() ![]() Joined: 24 June 2014 Location: Dumbarton Status: Offline Points: 670 |
![]() ![]() ![]() ![]() ![]() |
Can you change the speedo into a gear indicator on the 2008 R1 with this?
|
|
![]() |
|
rbengineering2010 ![]() fast Group ![]() ![]() Joined: 24 December 2013 Location: Gloucestershire Status: Offline Points: 227 |
![]() ![]() ![]() ![]() ![]() |
Hi mate, at the moment no as we are rolling out the main items the race teams have requested from us before going back in at a later date to do more features. I remember trying this with the Flashtune kit that was popular on yams but it only ever seemed to work on the USA clocks and ecu's for some reason, strange because they use MPH over there soit should have worked really. We will add it to the list of things to look into at a later date. Cheers Rich
|
|
![]() |
|
RedDevil ![]() Instructor ![]() ![]() Joined: 02 December 2012 Location: Berkshire Status: Offline Points: 1016 |
![]() ![]() ![]() ![]() ![]() |
So are there many benefits/gains to be made if fueling is already mapped by a pc5?
|
|
#92
|
|
![]() |
|
carsonr6 ![]() Racer ![]() ![]() Joined: 24 June 2014 Location: Dumbarton Status: Offline Points: 670 |
![]() ![]() ![]() ![]() ![]() |
I only ask because it was a Flash-Tune kit that I was looking into before I seen this post. £225 is a competitive price against the Flash-Tune kit though, so might need to do some research
|
|
![]() |
|
rbengineering2010 ![]() fast Group ![]() ![]() Joined: 24 December 2013 Location: Gloucestershire Status: Offline Points: 227 |
![]() ![]() ![]() ![]() ![]() |
Yes and no, things like throttle plate maps and ignition maps will also require fuelling changes. Disabling fuel cut etc will just make the bike much better on their own but will be even better again if mapped with fuelling also. I will tell you what I would do in my experience, I would wait until you have some time to work on your bike, SELL your power commander and get your ecu sorted, you won't look back honestly. I gave up on power commanders on both my own and my customers race bikes several years ago, I will not sl*g them off they do a good job of fuelling a bike, it's just they are limited to that. Cheers Rich
|
|
![]() |
|
rbengineering2010 ![]() fast Group ![]() ![]() Joined: 24 December 2013 Location: Gloucestershire Status: Offline Points: 227 |
![]() ![]() ![]() ![]() ![]() |
I will not diss their kit but will promise ours is very good. Cheers Rich
|
|
![]() |
|
RedDevil ![]() Instructor ![]() ![]() Joined: 02 December 2012 Location: Berkshire Status: Offline Points: 1016 |
![]() ![]() ![]() ![]() ![]() |
Have you got any examples of the power you have got out of 08 R6's?
|
|
#92
|
|
![]() |
|
rbengineering2010 ![]() fast Group ![]() ![]() Joined: 24 December 2013 Location: Gloucestershire Status: Offline Points: 227 |
![]() ![]() ![]() ![]() ![]() |
Hi Matt, as of yet I have none, this is a brand new product and the first ones only shipped today, the gains on a USA bike are huge like 8-10bhp and you will see this all over the internet. The UK bikes will only see about 2-3bhp at the top because the Electronic throttle maps are far superior on the UK bike in the first place. Seriously when we do a ZX6R for example people ask the same question, how many BHP etc? Again about 2bhp at the top, when they get it done they finally realise it's rate of acceleration where you see the biggest difference ![]() I will post up some dyno charts when they start coming in but believe me they tell you very little about how fast a bike is on the track. Here you go and this is just an example of what I was saying about the USA models, its a no brainer if you have one of those! ![]() Cheers Rich Edited by rbengineering2010 - 03 October 2014 at 20:23 |
|
![]() |
|
rbengineering2010 ![]() fast Group ![]() ![]() Joined: 24 December 2013 Location: Gloucestershire Status: Offline Points: 227 |
![]() ![]() ![]() ![]() ![]() |
Ok Guys, just got an update from Woolich Racing I am now in a position to offer Unlimited Flashing with the currently released R1 & R6 models, if this policy changes in the future then Woolich Racing will honour any purchases made before the change of policy.
In short if you buy a Yamaha Kit and Binfiles now you will get unlimited flashing full stop. If I can assist you further please contact me. Please see below:- ![]() |
|
![]() |
|
N8terider ![]() Racer ![]() ![]() Joined: 03 March 2011 Location: Epping, Essex Status: Offline Points: 920 |
![]() ![]() ![]() ![]() ![]() |
This sounds the business!
|
|
![]() |
Post Reply ![]() |
|
Tweet
|
Forum Jump | Forum Permissions ![]() You cannot post new topics in this forum You cannot reply to topics in this forum You cannot delete your posts in this forum You cannot edit your posts in this forum You cannot create polls in this forum You cannot vote in polls in this forum |